Page 20 of 33
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sat Jun 19, 2010 2:08 pm
by losthope
sanjuro what you running for parts on the mhr?carb,pipe,ect.? man i would think that bike is going to crank with that MHR and the burial pipe!
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sat Jun 19, 2010 4:22 pm
by sanjuro
losthope wrote:sanjuro what you running for parts on the mhr?carb,pipe,ect.? man i would think that bike is going to crank with that MHR and the burial pipe!
tm24 carburetor (35 slow jet and 160 main jet)
malossi variator (7.0 gram rollers), delta clutch, clutch bell, and kevlar belt
I'm gear limited right now to 57 mph, and running 9.71:1 kitaco primary gears. The pipe is excellent for the midrange, and it's got more but I probably need to put in 9:1 gears to see more top end. It gets to 57 mph in a hurry.
I've managed to put 286 break-in miles on the cylinder, and just got over 50 mpg during the last tank of gas. Also, today was the first time I did a WOT on it.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sat Jun 19, 2010 7:34 pm
by sanjuro
I just swapped out the 7.0 gram rollers and put in the 6.0 gram set I ran yesterday. The heavier rollers are not as good with allowing the pipe to do it's thing. Also, replaced the OEM front pulley drive face with an aluminum Chameleon. The bike is responding very well, but the only downside is the exhaust seems a ton sharper in pitch. My neighbors must hate me now.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sat Jun 19, 2010 10:47 pm
by bakaracer
what oil gas ratio are you running now?
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sun Jun 20, 2010 3:51 am
by sanjuro
32:1
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Sun Jun 20, 2010 4:51 am
by bakaracer
try a 30to1 mixture. give it that little more oil.with the aluminum cylinder you should be just right with the nice reving burial pipe.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 4:52 pm
by sanjuro
Wow, kinda surprised today when I did a WOT on an open straight with an upward incline. Managed to hit 60 mph on 9.71 gears.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 5:02 pm
by Wheelman-111
Greetings:
On those gears, that's spectacular. What RPM?
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 7:47 pm
by sanjuro
No rpm gauge, and the motor didn't sound too stressed.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 9:23 pm
by bakaracer
richen that oil to gas mixture.30to1 or 28to1 if the air temps get hotter.if its more than 100degs out you might have to even run a richer mixture. get a tach,that way you can see where your power band is hitting and tune for that area. the trailtech tto tachs are around $37-$40 shipped off ebay.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 9:39 pm
by sanjuro
I already switched it to a 30:1 mixture per your recommendation.
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 10:00 pm
by bakaracer
whats the air temp at where you live right now?
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 11:19 pm
by sanjuro
90-95 degrees
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 11:29 pm
by bakaracer
sanjuro wrote:90-95 degrees
thats getting up there.you might have to go richer on the oil to gas mixture if it gets hotter. watch the engine temps. what oil are you using now?
Re: Super Dio ZX AF28 build (not so super on pg 17)
Posted: Wed Jun 23, 2010 11:40 pm
by sanjuro
Honda gn2. My stage 6 egt is fried.