Page 1 of 1
engine is full of gas
Posted: Tue Jul 04, 2006 10:57 pm
by Dspecht
My Spree engine fills will gas so much the engine will not turn over. I am pretty certain it is coming from the fuel control valve vacuum line. This runs into the intake manifold and if it were leaking it would do this. The gas line is regulated by the float and valve so it cannot be getting into the cylinder this way as they are both perfect. Does the fuel control valve not have a diaphram in it or is it a rubber piston? Has anyone ever cut one apart to see whats inside and has anyone ever had this happen? harleyscooting
Posted: Wed Jul 05, 2006 1:07 am
by -aL-
are you sure you have the gas and vacuum lines hooked up right, not switched?
Posted: Thu Jul 06, 2006 12:03 am
by Dspecht
I have the bottom of the fuel control valve running to the intake manifold and the top off of the fuel valve running to the carburetor bowl. I left the bottom (smaller line) off last night and sure enough it drained about an inch of gas into the can I had under it. Apparently the diaphram has a hole in it and the gas is leaking into the vacuum line and then into the cylinder/crankcase.
Posted: Thu Jul 06, 2006 12:27 am
by -aL-
either a hole or its stuck open
Posted: Thu Jul 06, 2006 4:52 pm
by Farfignugin
wait...the gas drain out of the bottom (vaccume) line? That isnt good.
Posted: Thu Jul 06, 2006 4:57 pm
by -aL-
pick up a new petcock, it should solve the problem
Posted: Fri Jul 07, 2006 2:45 pm
by mopedman
i have a petcock to sell you if you need one, 15 bucks shiped
Posted: Sat Jul 08, 2006 12:53 am
by Dspecht
Thanks for the offer Mopedman but I bought one on Ebay ($25). If it don't work I will get back to you.
Posted: Tue Jul 11, 2006 11:41 am
by eman916
Hey mopedman,
Will that petcock, you're selling, work on an Aero NB50?
Posted: Tue Jul 11, 2006 2:19 pm
by MySpree
some spree ones will work on a honda aero... but not all.
Posted: Wed Jul 12, 2006 12:53 am
by Dspecht
I drilled the petcock through from the top and top hole, capped the vacuum line on the petcock and carb and the problem is solved till I get a good petcock. I bought one on EBay but it was worse than mine. It really leaked.
Posted: Wed Jul 12, 2006 11:24 am
by noiseguy
Contact Greg at
uspmale@yahoo.com or buy a good one from a member here. Send your Ebay unit back for a refund or give him bad feedback.