Page 1 of 1
85 honda spree
Posted: Fri Jul 22, 2005 6:25 pm
by generalsecord
no matter what i do i cant get the spree to idle normal.its running at about 60,and then quits i have tried everthing.need help
thanks
george
Posted: Fri Jul 22, 2005 9:17 pm
by tominos
how does your spree run 60?
rpms or mph?
85 honda spree
Posted: Sat Jul 23, 2005 7:30 am
by generalsecord
spree runs at a high idle.cant get the idle down.the adjustment screws dont seem to make any difference.when i start it up it takes off at high speed and then quits.when i stick my finger down insidethe air chamber i can get it to run normal,but the minute i take my finger away it starts going back to the high idle and then quits.need help
thanks
george
Posted: Sat Jul 23, 2005 11:57 am
by vette76
sounds like u dont have the filter/airbox hooked up.
honda spree
Posted: Sat Jul 23, 2005 12:07 pm
by generalsecord
yes the air box is hooked up.i put the new air filter in and the cover on and now it wont start.it just cranks on.still need help
george
Posted: Sat Jul 23, 2005 12:14 pm
by vette76
sounds like if its not that then the carb needs to be cleaned. its easy, and you dont need a rebuild kit.
honda spree
Posted: Sat Jul 23, 2005 12:26 pm
by generalsecord
no i cleaned the carb,but maybe i will clean it again.it doesnt matter what i do with the idle screw or fuel mixingscrew.
Posted: Sun Jul 24, 2005 12:16 am
by MySpree
you know it sounds to me like you didnt line the trottle thingy up witht he notch in the carb there you have to make sure it goes down all the way i dont think urs is
Posted: Mon Jul 25, 2005 9:02 am
by ferchja
You have a bad oring on the bystarter. Replace the oring and it will idle fine. Check my post on testing the bystarter vacuum and if that works you know 100% its the oring on the bystarter.
Main needle does nothing if the bike is at idle. Idle enriching circuit and the bystarter are the key to idle once the scooter gets warmed up.
If the little hole in the bowl is open to allow gas into the bystarter enriching circuit/needle than what you have is a vaccum leak around the bystarter to the outside air.
Posted: Mon Jul 25, 2005 12:32 pm
by MySpree
my scooter has no auto bystarter the thing it on just to close the hole but the neddle isnt there. i never had one when i go the scooter. so now i choke it by oinching the air filter wire.
Posted: Mon Jul 25, 2005 12:33 pm
by MySpree
choke it by pinching
85 honda spree
Posted: Mon Jul 25, 2005 1:03 pm
by generalsecord
i cant find ferchja's post on testing vacumn testing the bystarter.can you please help me.find it.
Posted: Mon Jul 25, 2005 2:03 pm
by vette76
i believe it is in tech documents.
Posted: Mon Jul 25, 2005 2:54 pm
by ferchja
http://www.hondaspree.net/modules.php?n ... tarter[url][/url]
It's in this post go about 2/3rds down the page. You'll see it.